Car paint room, furniture paint room, industrial spray paint room, sheet metal paint room, factory direct sales

型号

Luxury BJ9200

参数

内尺寸: 6900*3900*2650mm（L*W*H）

Inside Dimension: 6900 * 3900 * 2650 mm (L * W * H).

外尺寸: 7000*5350*3350mm（L*W*H）

Outside Dimension: 7000 * 5350 * 3350 mm (L * W * H).

正面门:无包边手工门，3扇大门，折叠门尺寸：3000×2600mm（W×H）颜色与墙体一致

Main Door: No border manual door, 3folds，folding door size:3000 * 2600 mm (W * H)color consistent with the wall.

工作门：一扇600*1800，工作门配两个压力锁，颜色与墙体一致

Personal Door: One fan 600 * 1800, 50 mm thick, EPS wallboard production, aluminum alloy binding, with two pressure lock.

墙板:采用50mmEPS(聚苯乙烯)插口型保温板

Wall Panel: 50 mm EPS (polystyrene) mouth insulation board, galvanized roof.

顶板:采用镀锌钢型板扣装组合，这种钢板既具有卓越的防锈性能，延长其使用寿命

Roof:Galvanized steel panel

地台:270mm高的全钢制拼装式，两道花纹板，三道地格栅，二个520*2000mm（W*L）上车坡
basement: Complete steel assemble 270 mm thick, two decorative pattern plate, three grille, two car step 520 * 2000 mm (W * L).

照明系统:上排斜置45°专用烤房倾斜顶灯，8组×3支=24支，每支36W，下排灯8组×2支=16支，每支36W，光照度≧800Lux灯箱用冷板制作

Lighting System: Lamp boxes are 45° fixed on upper two side:With8groups*3pcs=24pcs*36 W, side lights:8groups*2pcs=16pcs*36W,illuminate≧800 Lux.

机柜装置:侧上进风、方管钢框架、阻燃型聚苯乙烯泡沫板蒙合制成，结构稳固、牢靠、美观、便于维修保养。烟管采用0.6镀锌板制作，3节700×700×1000mm的直管，一个90°弯头，并配有专业角码法兰。

Rack device: Intake air form the edge upper, aluminum alloy frame, EPS wallboard production, coated steel.Air duct made of Galvanized plate(Thickness is 0.6mm),700*700*1000mm,3 pcs straight,1 pcs elbow.

进风机:采用引进西门子技术生产的YDW系列离心式风机，此风机具有噪音低，风量大，能耗少等优点;流量:12500m3/h;全压800Pa；转速：900rpm；功率：4KW；数量：2台

Intake Fan: 2 * 4 KW double inlet air centrifugal fan, air volume of 25000 cubic meters/hour

排风机
1台*3KW轴流式排风风机，风量25500立方米/小时，转速：1450rpm

Exhaust Fan: 1 * 3 KW air volume of 25500 cubic meters/hour

加热系统:红外线加热系统，左右墙体各加装3组红外线烤灯，后侧墙体加装2组，一共8组，每组3KW（含3支红外线烤灯，每支1KW）最大发热量24万大卡，该系统以极强的红外热辐射为热源，无需通过介质转换直接辐射被加热体，在空间沿内形成宽谱波定向辐射，使被加热体由里向外快速干燥。

Heating system: infrared heating 8*3KW, the maximum heat 240000 calories, the highest temperature of 80 degrees Celsius

过滤系统
初效过滤、高级顶棉过滤，初效进风过滤为优质过滤棉, 有效捕捉大于10μm的尘粒; 顶部高效过滤, 有效捕捉大于5μm的尘粒;

Filtration system:Early effect filter, advanced cotton, inlet air filter for high quality filter cotton, effectively capture the dust particles greater than 10 microns; At the top of the high efficiency filter, effectively capture greater than 5 microns dust;

电控系统
采用优质电子元件组装, 主回路设有多重保护; 照明开关、喷漆、升温喷漆、烤漆温度、时间设定、故障指示灯

Control system: lighting switch, spray paint, spray paint of temperature, drying temperature and time setting, emergency stop, limit the warm, failure alarm.

电压频率:380V 50HZ

Voltage Frequency:380V 50HZ

总功率：36KW

Total Power:36KW